Lexus ES: System Description
SYSTEM DESCRIPTION
GENERAL
(a) The rear window defogger wire (back window glass) is attached to the inside of the rear window and defogs the window surface quickly when the rear window defogger switch is pressed. The indicator light on the switch illuminates while the system is operating. This system automatically turns off after approximately 15 minutes.
NOTICE:
If the battery voltage becomes low, battery load control will operate in order to ensure sufficient power is supplied to the power steering system. In this case, the window defogger system may not operate.
HINT:
-
If both of the following conditions are met after approximately 15 minutes from when the window defogger system was activated, the window defogger system continues to operate up to approximately 45 minutes. If the following conditions are not met, the window defogger system stops operating immediately.
- The outside temperature is -3°C (27°F) or lower.
- Power generated by the generator assembly installed to the vehicle is stable.
- The window defogger system is linked with the mirror heater function.
FUNCTION OF MAIN COMPONENT
| Component | Outline |
|---|---|
| Rear Window Defogger Switch (Air Conditioning Control Assembly) | Sends signals to the air conditioning amplifier assembly to operate the window defogger system. |
| Air Conditioning Amplifier Assembly | Sends a window defogger system activation request signal to the DEF relay. |
| DEF Relay | Receives a window defogger system activation request signal from the air conditioning amplifier assembly and supplies power to the rear window defogger wire (back window glass). |
| Rear Window Defogger Wire (Back Window Glass) | Receives power from the DEF relay and heats the rear window using the rear window defogger wire (back window glass). |
READ NEXT:
How To Proceed With Troubleshooting
CAUTION / NOTICE / HINT HINT:
Use the following procedure to troubleshoot the window defogger system.
*: Use the Techstream.
PROCEDURE 1. VEHICLE BROUGHT TO WORKSHOP
NEXT
Operation Check
OPERATION CHECK CHECK WINDOW DEFOGGER SYSTEM (a) Turn the engine switch on (IG). (b) Check that the rear window defogger wire becomes warm by operating the rear window defogger switch of the air condi
Problem Symptoms Table
PROBLEM SYMPTOMS TABLE HINT:
Inspect the fuses and relays related to this system before inspecting the suspected areas below.
Use the table below to help determine the cause of problem symptoms.
SEE MORE:
Right Electric Parking Brake Actuator Control Circuit Open (C061013)
DESCRIPTION DTC No. Detection Item DTC Detection Condition Trouble Area Memory Note C061013 Right Electric Parking Brake Actuator Control Circuit Open
Diagnosis Condition:
Electric parking brake not operating
Malfunction Status:
The ECU power supply is normal but there is a
Installation
INSTALLATION PROCEDURE 1. INSTALL FUEL MAIN VALVE ASSEMBLY (a) for Type A: (1) Apply gasoline to 2 new O-rings. Then install the O-rings to the fuel main valve assembly. (2) Install the fuel main valve assembly to the fuel suction tube with pump and gauge assembly. NOTICE: Make sure that the O-rings
